Anyone place HD Leafs on NON lifted cart?
Curious if anyone has done this and how the cart rode. My thinking is the HD leafs might provide a stiffer ride, but the long term life span will be far extended. Thoughts? Any input is appreciated...
View ArticleSeries or Sepex
I have a 2002 CC DS 36v series motor that I converted to a 48 volt system about 4 years ago. (Thanks Scotty B.!!) It is lifted with a rear seat and 22 inch tires. I have an AXE 4855 in it that is...
View ArticleStarting Problems Carb Maybe?
I have a 1985 EZGO. I overhauled the engine and carb. in 2014. New filter, Belt,and gas cap. The cart ran without a hitch all last year. I put in fresh gas with sea Foam and and ran it for a while then...
View ArticleDead Batteries
I have had a 1999 Yamaha golf cart for 5 years and never had a problem charging until now. I understand the batteries need to have at least 44volts so the charger knows its hooked up to batteries. My...
View ArticleHelp hooking up volt meter 07 TXT PDS
I'm trying to hook up a little 36V voltage meter and I can't seem to get any voltage reading when testing at the key switch either on or off. I wanted to hook up to key switch and battery so it is not...
View ArticleTrojan T875 or Ranger 160s?
It's time for batteries. Seems the T890s aren't available anymore. Run maybe 8 to 16 miles per day, mostly morning and evening, and can charge in between uses. Some hills but nothing to challenging....
View ArticleSlow cranking
Have a 84G1 2 stroke...last few times last year at race track noticed eng turning over very slow..to so slow almost can't feel or hear at..battery checks out good..even put charger on it to make sure...
View ArticleManual for 94 EZGO Marathon?
I have searched the site, but can't find a manual for the 1994 EZGO Electric Marathon. Does anyone have one or can you direct me to the proper place?
View ArticleWtb club car 36 Volt Charger
I'm near Sandusky Ohio but will drive . Anyone got one for sale 36 volt club car charger Also looking for new batteries or newer Owner at WickStick Stabilizers
View ArticleG14 Brake Return Spring Replacement
New to the forum. Have a '96 G14 with a shot brake return spring. I have a new one but can't get the bolt out to replace it. Not much room below the floor to get a good hammer on it. I guess I need to...
View ArticleG14 Brake Return Spring Replacement
New to the forum. Have a '96 G14 with a shot brake return spring. I have a new one but can't get the bolt out to replace it. Not much room below the floor to get a good hammer on it. I guess I need to...
View ArticleBypass governor
With the cable from throttle to the governor sticking, can you bypass the gov. and go from gas pedal to throttle on carb and leave gov in full open position, letting throttle control speed.
View ArticleController help please
Just purchased Sevcon 633T45319 to replace the old PRO99050. Programmed and purchased from a Columbia dealer in Florida. I hooked it up the same way it was before. When I place the switch from tow to...
View ArticleEngine rebuild or ?
I have to make a decision and I'd like some input. I have a 2006 gas txt that I use to feed animals and for other chores around the property. The cart normally runs for short distances and only gets to...
View ArticleALERT: 22HP Predator ON SALE... Harbor Freight
Just thought I would throw this out there. HF has the 22hp Predator V-twin on sale for THREE days(Fri,Sat,Sun)...this weekend.......$549.99 http://www.harborfreight.com/22-HP-6...c0In0%3D%0D%0A with...
View ArticleAll Sports long travel adjustment
I've got my All Sports long travel all installed and toe-in adjusted. How do I get the upper and lower ball joints loose so I can adjust camber? It can't be that hard to do right?....I just cant figure...
View ArticleMotor Upgrade (Speed)
Hello, I am almost done with my rebuild....worked on the wiring tonight. So it now has the 500 amp controller and all 2 ga wire. My question is should I also do the motor while I have the body off? I...
View Article1991 EZGO XT-500 Turf Cart (Marathon) stopped moving
My cart stopped functioning, I have replaced the F/R switch and also pretty sure the solenoid is functioning properly. All contacts have been cleaned. I've been trying to follow the diagnostic sticky,...
View ArticleClik here to view.
Which Trailer Hitch
From the 2 pictures, can you tell me which type of hitch to buy? Thanks, Al
View ArticleWhat oil is best for the Yamaha G1 engine?
Having just finished the overhaul of my Yami G1 engine, I'm trying to wade through the mysteries of the 2-cycle oils available. The 35 year old service manual says: "Use Yamalube Golf Car oil or, if...
View Article