89 3pg Cutts off and refries with new plug
OK I cleaned all the gunk out of the muffler by cutting open and removing all the plugged junk in there and now after the motor gets hot it will cut off and won't start unless you put a cold plug in it...
View ArticleClik here to view.
Glow Shift tachometer install
I have been reading up on several past threads about installing tachometers. I found a lot of good information but have not found anything that refers to the glow shift tachometer using the negative...
View ArticleYamaha G1
Okay I'm new here. Just got my first golf cart. It's a 1982 Yamaha G1. I know just my luck. It has a bad motor and all I can find is kits for everything but 1982 motor. What are my options? Can I just...
View ArticleClik here to view.
1999 Villager 6 Factory Flip Seat
Hey everybody, this forum has helped me a great deal with my two gas DSs, and I'd like to thank everyone who has helped. I'm currently in the process of "restoring" a gas Villager 6 formerly used as an...
View ArticleGE IQ Motor
I just pulled this motor out of my 2002 for an upgraded motor. It runs perfectly. It is a GE 3.2 HP Special Service complete with speed sensor. This motor is fully compatible with all IQ carts (DS and...
View Article1987 ezgo gas crankshaft bearings specs
Hello everyone new to the forum here. I have a 1987 ezgo gas cart and I'm inherited rebuilding the engine which has been a pain and has made me test my religion :pain10::pain10: I have everything apart...
View Articleslow down
1985 elmco cart 48 volts does 31 in forward which is fine. however reverse is kinda jerky at first when you give it pedal is there a way to slow it up in reverse at the beginning it jerks just a bit...
View ArticleEZGO TXT electrical
Cart is hesitating when pressing on the petal. Have changed the mircro switch and resister. It is still acting this way. Does anyone know what the problem might be? Or a diagram on which part to test...
View ArticleClub Car 2003 1/2 hub
Hi - First time poster, so please be gentle! I've owned a 2003 Club Car DX S/N: AA 0329-3000803. I stripped a stud in a front hub while trying to replace a leaking front wheel. I assume that I will...
View ArticleMpt 1200 transaxle
Got this cart on bid at work on a silent auction as is, runs fine in forward, put in reverse the rearend locks up, knew to gas carts have several electric carts so any help would be appreciated.
View Article1983 ezgo gas
Greetings I am new to this forum and looking to locate a wiring diagram, repair manual and any information installing a accelerator switch for a 1983 Gas EZGO with 2-Cycle Fuji-Robin Engine. My son (...
View Article86 Marathon trailer hitch
I want to put a trailer hitch on my 86 Marathon, anyone know where I can get one?? Thx, Mike
View ArticleBad back bearing?
Pretty sure I know the answer to this question but figured I'd get more opinions before I tear into it..1999 txt, was cruising yesterday stopped for a minute and set the p brake. Released the p brake...
View Articledoes anybody have a good way of getting batteries out of a cart?
Since there is going to be a battery change in the near future, I have bee trying to figure an easier way to get the batteries out and back in the cart. I have some spar bar 3x3 square bar with holes...
View Article2012 Gas RXV price?
A local dealer in my town has a 2012 Gas RXV he is selling for 5400 + tax. Has a 5 inch lift, 12 inch wheel/23 inch tire, rear view mirror, rear view seat, windshield, signal light, and signal sign on...
View ArticleClik here to view.
Custom G2 Front Suspension
I started working on my cart back in January with the idea of having a closed cab and heat. LOL After replacing the carburetor - insulator and air cleaner -- I found it was a smoker choker drive you...
View ArticleVanny Done with video!
All done (minus temporary air filter)!! Rev kit, Comet 780, cam advanced, flywheel advanced, Magnaflow muffler 2 1/2". Hopefully finishing air filter tonight. https://www.youtube.com/watch?v=H3aAGVILwbo
View ArticleDry Moly Lube
What is can be used as an alternative to the Dry Moly Lube? I haven't been able to locate any around me.
View Article2012 Gas RXV price?
A local dealer in my town has a 2012 Gas RXV he is selling for 5400 + tax. Has a 5 inch lift, 12 inch wheel/23 inch tire, rear view mirror, rear view seat, windshield, signal light, and signal sign on...
View Article