200 club car 48 volt reverse problems
Hello, cart runs fine in forward, in reverse very slow , shutters and motor gets very hot. Batteries all check good. Any ideas? Thanks, Brad
View Article97 TXT 36v Will not move
I have a 1997 TXT 36v with brand new batteries and cables. Solenoid clicks when key is turned on and reverse buzzer sounds when put in reverse. I was able to go forward about 30 feet (only slowly) and...
View ArticleHooking up headlights and a reducer. Distribution block?
I just ordered a headlight/tail kit and a 48-12 reducer to run everything on. I was planning on putting in a couple player as well soon and rather than having everything oring terminated or nutted on...
View ArticleClik here to view.
Slow 99DS Wired Wrong ?
Have a 99 DS resistor cart. It barely does 11MPH and if we had hills in the Lowcountry, I'd probably be pushing it a lot. I was cleaning terminals saw the green wire going to F/R switch. I looked up...
View Articleezgo txt pds not going forward or turning off
I have an ezgo pds with a new alltrax dcx500 and D&D motor, the key switch will not turn off the controller and it goes in reverse on both positions. I replaced the key switch, f/r switch,...
View ArticleClik here to view.
ezgo 1204-027 controller troubleshooting guide
A friend I work with that just retired, has an older ezgo golf cart. He took it to a local shop and they told him the controller is bad. He also needs new batteries, so I wanted to make sure it is the...
View ArticleRear End swap from pre 96CCW to a CW
My Club Car Carry All is a 1996 of course it came with a CCW FE290, was forced to replace with fresh FE350 CW. Yes I am forced to run in reverse for forward. Now that every thing a running correctly...
View ArticleClik here to view.
G16 Brake Drum Won't fit over Shoes
Removed the old shoes cleaned all up. The adjuster slides back and forth the adjuster screws are all the way in. Bought new shoes from a Yamaha dealer, installed them got all the springs in place but...
View Articlelow Battery voltage on one battery
I have acquired a 1996 ezgo txt dcs 36v, Just got referb t105's batteries 2 months ago, during the time had put a new controller on. Finally started riding noticed one battery was warm on the side,...
View ArticleFound Sticky, Nevermind...
Hello, I had posted asking for help diagnosing an issue, but quickly found sticky up above. Don't see how to delete. Will use that link. Sorry. Hello, My lease mates and I have upgraded a 2006 EZGO TXT...
View Article2012 Yamaha
I have a 2012 Yamaha that shuts off in the middle of operation, but if the tow/maintenance switch is toggled, it will reengaged the motor and begin to operate. This happens several times during a...
View Article99 DS, one speed, All Out!!!!!
Hello, My 1999 48V DS seems to only have one speed. Fast!!! No mater how gently you apply the gas pedal as soon as the solenoid clicks it lurches forward or reverse dependent on the shift lever...
View Article83 club car motor wire
I need to find a replacement cable for an 83 club car. I'm trying to find the cable that goes from front drivers side battery back to motor. All I can find is full set. I just replaced other cables and...
View Article2008 Bad Boy Buggy won't move
Batteries are charged and the indicator light shows full when key is switched on. However there is no response at all when the pedal is pushed (forward or reverse). This buggy was inherited in this...
View Article1986 ezgo 2 cycle will not start.
Ok guys i rebuilt ezgo 2 cycle motor. Everything is hooked back up and we can get it running by putting our hand over the throttle. Other tham that it cranks and cranks and cranks. Compression is about...
View ArticleWTB: 89-93 EZGO Battery Cables
I recently picked up an 89 EZGO electric cart. I need a set of battery cables. Just looking for a decent used set.
View ArticleClub Car Precedent Stutters and Headlight Pulsates
I am hoping someone can help me out. I just Received my upgraded "Bandit" motor from Plum Quick motors for my 2011 Precedent Club Car and immediately after installing the motor I had the following...
View ArticleShow me your Dash!!
I'd like to see what some of y'all have done for a dash or console on your Club Cars!!
View Articlewtb clutch
before I order a new one, does anybody have a comet 780 clutch they would be willing to sell.
View ArticleClik here to view.
1993 Ezgo cart
Have a 1993 Ezgo gas cart I bought for no reason. I need to sale it. It's pretty much stock except for the lift and wheels tires. Motor runs fine but I have no idea how many hrs are miles are on it. It...
View Article
