Getting rid of torque converter putting in sprocket. need help!!
I have an EZGO txt and I'm doing an engine swap putting in a Kawasaki 350 motorcycle engine. Problem is I have to remove the part of the torque converter on the rear axle and put in a sprocket. The...
View ArticleNeed help swapping torque converter on rear axle to sprocket driven!!
I have a gas EZGO txt and I'm doing an engine swap putting in a Kawasaki 350 motorcycle engine. Problem is I have to remove the part of the torque converter on the rear axle and put in a sprocket. The...
View Articlegetting more ground clearance
I have a 2000txt with 18x8.50-8NHS tires . We seem to have good wheel clearance. We are trying to get slightly better ground clearance without adding a lift kit. Any suggestions appreciated. Thanks
View Article01 club car 48v series randomly dies
My cart has brand new batteries and controller and will work fine then suddenly dies down. All connections are correct and tight. It moves slow in reverse when it's working fine but will barely move at...
View ArticleCart is a no go
89' marathon, still a toaster oven. I drove the cart about a mile and parked. When I got back in about 30 minutes later, nothing. No forward, no reverse, no clicks, pops, sparks, or anything. The...
View ArticleBattery Replacement for TXT
I am having some trouble determining the correct battery that should be used in my EZGO TXT. The cart I just purchased the battery was shot and I need to get it replaced. The one that was in the cart...
View ArticleSpeeding up my 2012 PDS TXT 48V
I'm very new (1 week) to carts. Purchased one and got it last week...works great...looks pretty good...but the top speed per my GPS is 12 MPH. I'd like to get that up to the 18-19 most seem to enjoy....
View Article2004 G22 Yamaha, start and stop problem
Cart wasn't running so I replaced, coil, fuel filter, hoses, fuel pump, and carb. Now, have to pump gas petal, slowly, sometimes it only takes two or three pumps, sometimes it takes 5 minutes. Once it...
View ArticleInstall rain cover cabana
I am installing a OEM Club Car cabana for rain protection of golf clubs on back of a 2010 Precedent. The 2 arms bolt to the frame using the same bolts for the bag rack. When using original screws they...
View Articleneeds some electrical help 1996 carryall
Hi guys. Well it finally happened the motor fe290 took a dump sent the cart out for what I hopped would be a simple rebuild to make a long story short that didn't happen. Well the folks there know me...
View ArticleTow/run
The 99 DS regen 2 that I sold a while back to a friend and I guess am still responsible for has a problem. It seems sometimes he has to place cart in tow then back to run in order to get it to go after...
View Article06 carry all speed?
06 carry all 6, 48 volt, it is a series. Just curious does 8 mph on the flat sound right for top speed?
View ArticleClik here to view.
Tire tread question
Wierd tread wear. Not sure why. The tire pressure has been at 15psi Sahara classic 22×11-12 Id like to figure this out before putting new tires on. Anyone have any thoughts? All help is appreciated...
View ArticleMaking a replacement wiring harness?
My wiring harness is in rough shape because of age and exposure to the elements. As a result some of the wires are becoming brittle and most of the connectors on the ends need replacing. Has anyone...
View ArticleClik here to view.
My new wheels
My new 12x7 blue stormtroopers. With 23x10.5 x12 tires. Attached Images image.jpg (315.7 KB)
View ArticleG1 gasket for oil pump housing and for oil pump?
Can't find them anywhere. I haven't decided on removing it yet so if I keep it I'm going to need them. Or do I?
View ArticleClik here to view.
Bagged, chopped, stretched Model A inspired 78 club car rat rod
A few of my friends wanted to build "rat rod" carts. What did they do? Slap on some flat black primer and red wheels. That isn't a rat in my book. So I thought I'd raise the bar a little. My plan is to...
View Articleelectrical system upgrades
alright all, finally pulled the trigger on some electrical upgrades. (i'll bet scottyb is thrilled i don't have anymore pre-order questions.) i am starting this thread as i am sure i am going to have...
View ArticleClik here to view.
Wiring question on my 89 ezgo/cushman xi 500
Hello all I am now the proud owner of an 89 ezgo xi 500 the same year I graduated from high school. I have started going through her and attached to the toggle switch which I'm reconnecting to the 2...
View ArticleSpeaker amplifier switch wiring
I am trying to connect a Bluetooth amp to my 12v reducer. The instructions say: Red +12v switched Black is ground Yellow is +12v battery Please also note I have a Harley Davidson ignition w 3 wires....
View Article