Another "won't turn over" topic
I have the 295cc EZGO engine i just replaced piston rings head gasket carb gaskets and exhaust gaskets. I thought the engine needed to be bored until I looked at the cylinders they looked like new so...
View ArticleClik here to view.
Added 2" to lift blocks
Had to add 2" to the lift blocks for clearance with 26" tires. Attached Images image.jpg (144.3 KB)
View Article2002 TXT 36 Volt only goes slow after repairing the motor
I replaced the spline on the electric motor on a TXT. Job went smooth. I put the motor back in and wired it up. The motor started fine for about 30 feet, then seemed to slow to a much lower speed. 1....
View ArticleClik here to view.
New owner of 1973 HD DE4 electric golf cart
Without asking me, my wife bid $245 on this 1973 Harley Davidson DE4 electric golf cart and won it. It was only 75 miles away, so we just picked it up today. It came with a 36V Lester charger. The...
View ArticleClik here to view.
G9 Speed Gear HELP!!!!!
I'm installing a set of speed gears on my Yamaha G9A rearend. I've got it all apart and upon isntallation of the new gears, from CPP, I found that the ID Of the final drive gear, the big one that is...
View Article23 HP cam, has any one advanced it
One tooth to see what it runs like? I know Don has said to advance the stock cam one notch but has anyone tried the 23 HP cam advanced? Doe anyone have the specs on the 23 HP cam so that I might...
View ArticleClik here to view.
Lifting a 1989 Club cart
Hi, iam new to all this but I've bought a 1989 CC series I belive with the V Glide. Iam looking to put a lift kit now that I have it working. My question is can I lift the front end without purchasing...
View ArticleClik here to view.
89 EZGO 3PG Part out
I got a 89 EZGO with a 3pg motor that runs pretty good. I'm going to part it out. There's throttle parts missing so I rigged it to crank the S/G from a rocker switch and I had to feather the throttle...
View Article08 Precedent Not Running
Having an issue with my 08 Precedent. The cart will not run. Batteries are 2 years old and charge fine. The selenoid does not engage when the pedal is depressed. I replaced the selenoid, but still did...
View Article1992 Club Car runs sluggish at full throttle
I have a 1992 club car that runs like it should at the start, at low rpm's, I push on the gas a little more, until halfway and it runs good and increases rpm's. But once I push it to the floor the cart...
View ArticleAnother broken windshield
Well I've broken 2 tinted windshields on my 2015 Yamaha drive one hauling it on my trailer going down the road and the was just drives get on pavement they keep breaking on the passenger side were it...
View Article1997 EZGO Gas takes awhile to come up to full revs
I just acquired a 1997 EZGO TXT and while I am well versed in all things large and small engined, it is my first golf cart. The whole concept of something not even starting until you hit the gas is...
View ArticleLED lights fried?
I am working on a 48v TXT that has had an entire LED light kit installed. There is no voltage reducer, the lights are running off of two 8v batteries so their getting 17 volts. The rear tail lights are...
View ArticleClik here to view.
Painted my Ezgo Black and is paint came out lumpy
First time painting so had/have some issues. I used summit hot rod black urethane paint and could not get my sprayer to spray right. The paint came out blotchy and rough. I put 4 coats of black but did...
View ArticleLong travel shocks
I'm starting on my long travel build. I have three options for coil over shocks right now. 350 rancher, 250ex, and some moped shocks. All are coil over. The moped shocks have the most travel, the...
View ArticleEZ-GO Txt 48v with AXE - No solenoid Click - New Solenoid
EZ-GO Txt 48v with AXE controller - Replaced the solenoid - No solenoid Click Bought a heavy duty solenoid from club car .. Used diode and resistor, can't get it to do anything. I checked the micro...
View Articlecontroller
will a controller wear out or just go bad? someone told me that my controller was probably going bad because my golf cart speed wasnt up to par.(matches my golf game!!!!) Im sure this is in a thread...
View Article2003 TXT Engine Runs Perfect, Won't Move Then....WHAM
I have a 2003 TXT Gas that up to a year ago ran better then perfect. The problem has started slowly but has become worse. When I push the accelerator the engine revs normally but the cart does not...
View Articleclub cart stops and goes
I have a 2004 48volt club cart ds that when you press the accelerator it takes off nice but once it reaches top speed it stops, I release the accelerator and press it again and it continues going. This...
View Article