More Power
Moved light sensor to dash. 400 watt amp will be added to stereo and 2 more 6x9 speakers will be added too.
View ArticlePossible clone swap
I have an '87 club car that I'm possibly interested in doing a clone swap. I'm curious as to what engines people have had most luck with. Another question I have is will my cart still start and stop...
View ArticleRear driver side tire creaking when applying brakes.
While it currently seems to have no effect on cart, when I apply brakes rear left makes an odd creaking noise? Any ideas?
View ArticleWheels and tires
What's the biggest wheels I could put on a 94 CC DS without a lift kit?
View ArticleEZGO no reverse
I am a newbie with golf carts and need a little help. I have 98 EZGO TXT. The forward / reverse switch is down next to your legs on this cart. No problems going forward. When you move the switch to...
View Articlewtb club car gas project
looking for a club car gas for a project non running would be great anybody near wv willing to travel thanks
View ArticleWill an upgraded motor solve my problem?
Any education or advice for my situation below is appreciated. I recently presented a problem on this forum about my electric motor overheating (260 degrees) on my newly purchased 2002 Club Car DS IQ...
View ArticleEZ Go 2pg HEI conversion help
Hi I just purchased a ez go golf cart with a 2pg robin motor. The fella I bought it from said it didn't run because the condenser is busted. So i purchased a new one and that still didn't do anything....
View ArticleLooking for a working 1974 harley drive clutch
I'm looking for a good drive clutch for my 1974 harley cart.
View Articleelectrical issues
my gas medalist won't stay running. I charge the battery and it will run for 1/2 hour or so. I replaced the brushes in the starter generator thinking it was not charging the battery appropriately, but...
View ArticleClik here to view.
If you are having starting issues with VC 460.. (CC 84-96)
To start off, the VC starter/gen belt is a complete waste that is incorrectly sized for our application. Not only that, but VC would not offer me any alternatives or even issue out basic replacement...
View ArticleHelp with a 1986 DS
Im new to this side of Buggiesgonewild web site. I have an Ezgo so Im mostly over on that side. I could use some help from you guys on a project I have. The lady two houses from me is 90 years old...
View ArticleEZGO Performance Motor?
I am looking for a new motor for my Series cart. I am looking for top speed of 25 with maximum torque. D&D torque motor can only get me 19 mph with my set up (see signature for set up). I contacted...
View ArticleMay be selling 14hp Vanguard engine w/trans and rev
Hey All, I've been like the quiet little sniper, using and abusing this awesome forum for all of my 4 golf cart builds this summer. Scotty doesn't know it, but his advise to others was a huge help....
View Article2008 TXT PDS cart running HOT!
I have a customers 2008 EZGO TXT. Mods include: 6 inch lift, 22 inch off road tires, 400 amp Alltrax controller, 2 gauge cables, and now a high torque motor from red hawk. the battery pack isn't...
View ArticleCart charges 2-3 hours only drives 10 minutes
I just bought a 2005, 48 Volt Club Car. It looks to have 3 2013 batteries and 1 2015 batteries. The dealer told me the voltages are all good but I have not checked them myself. When I charge it goes to...
View ArticleG1 "Absorber"
On the subject of my G1 engine work (to be continued in the other thread), what does the "absorber" absorb? Is it needed, or nothing to worry about? (Here it is depicted on the TNT Carts site, Item #8:...
View ArticleGetting ready to go enter the cart world.
I've been lurking here for a while and reading lots of posts and now I'm getting ready to take the plunge into the cart world. Here is where I need help from all of the collective experience here. I'm...
View ArticleQP serial number
I recently purchased a club car with the serial number beginning with QP. I can't seem to find much information on this. Everything I see for similar years has a different prefix and I'm curious if...
View Article2003 ds steering problem
I need help on my 2003 DS. The steering had gotten really bad play from 9 to 3 without any tire movement I had checked all the tie rod ends and they were completely shot. UncleJerm sent me replacement...
View Article