Signal flasher
When I started my rebuild my lights, brakes and signals worked. Now all but turn signals works. Not sure how to test the signal relay or do I just replace? Where can I purchase the 12v relay? I removed...
View Article48v cart intermittently stops
Have had my cart at auto electrician and they have run all tests. Advised me to replace Curtis controller 1266-5201, which i have purchased through China. Would this be programmed to just fit? A the...
View Article1996 Ezgo txt 36V Beeping when key is off!
I'm new to this forum and I'd appreciate some help. Cart worked fine; drove it home and plugged it in; several hours later it started to beep when keys off. I unplugged it and switched it to...
View ArticleEZ Go DCS
EZ Go DCS When put in reverse it still backs up when shifter is moved to forward..Anyone had or having same problem..
View ArticleBending pipe
Have any of you had experience with bending pipe? I'm seeking to bend pipe to build a roll cage. Probably a one time deal. What equipment did you use that worked well for bending 1" pipe.
View Article09 RXV EZGO Powerwise QE Charger ?
Didn't want to hijack a thread & I found the thread with the code faults. But my charger is flashing 5 red lights. Actually it flashes, green,red green,red 5 times & finishes green then...
View Article16hp vs 18hp
I have a 16hp Vanguard that I bought a couple of months ago. I bought it because I couldn't find a 18hp or larger. I haven't started the build in my '02 EzGo, but just came across a 18hp Vanguard for...
View ArticleFree to a good home
Just put a rear flip-down seat on my ride and have some factory parts that I don't need and would probably have a hard time selling them...so they are free to you. Will ship on your dime. Club Car DS...
View ArticleKey switch plate SOC meter hole size
Anyone know the size of the opening on the key switch plate that has the SOC hole cut already? If I would order it would be the horizontal one. Thanks
View Article1990 Series speed controller replacement for Curtis 1204-009?
I've got a 1990 EZ-GO cart that has the series motor. It's not the DCS. I've tested the current controller (Curtis 1204-009) and it tests out bad so I'd like to replace it. My dad is a Stens dealer so...
View ArticleClub Car DS 48 volt Shutters or Jumps pumping pedal
I have a 2001 Club Car DS 48 volt, 550 amp controller, All 4 gauge cable, 11 HP motor with back fan. Brand new batteries all checked out perfect with a load on the batteries and Hydro test. I get into...
View Article1998 TXT strange troubleshooting issue
Friend of mine's grand-dad uses a 36V EZ-GO to get around his property (check the mail, etc etc). He thought the batteries were getting weak so he replaced them (they were, by all accounts, bad) and...
View ArticleOBC Help '09 Precedent
So I thought my charger was bad but ruled that out today by checking it on a working system. Cart runs and has 48.6V but charger won't kick on. If the charger is good does that just leave the OBC? How...
View ArticleRebuilding ezgo
I am rebuilding a 1995 ezgo medalist gas cart for my mother. It currently had the 295cc Fiji in it. She wants a little more power out of it I already did custom clutch work shorter belt . She would...
View ArticlePar car 1990 NO POWER
My par car first ran good. Then the sparkplug went out Replaced it and it ran again. But with NO POWER. The engine will not rev up. Runs smooth stationary. Changed the piston rings and cleaned the...
View Article1984 Columbia Having engine power issues
So i will start off with have been working one this cart a few years now. The problem i am having is that when running the cart there is no power going forward. Engine starts and runs fine but breaks...
View ArticleTrailer hitch for txt with rear seat
I did some digging around the forum, but didn't find anything specific to what I am looking for. Does anyone know of a hitch that is available, that will install on a 99 txt, with a rear seat, the foot...
View Article87 EZGO Reverse buzzer Stuck on
Hey ladies and gents i got a 87 ezgo and just recently the reverse buzzer is stuck on, i can drive the car in fwd or reverse no problem but the buzzer does not shut off even when the key is in the off...
View ArticleChager problems
When charging my 2007 ez-go txt the charging cycle is only lasting about an hour. And my run time is not long before i can tell the cart is going dead. When I use my neighbors chager it will charge...
View ArticleCharging issues help
I have a 2009 Yamaha cart it came with a JW2 H2107 03 CHARGER. It just started today but when I plug the charger in lights on the charger all come on then the top red one stays on just a second and...
View Article