Stereo system ideas
Looking for some input from you guys who have installed stereo systems. I want to add some decent quality speakers, sub, and amp to my cart. Looking at Polk db651's for the speakers. Not sure about amp...
View ArticleClik here to view.
What does this vin number tell me
5K 22471 C7 my cart ran great last year then it slowly started to have trouble moving and then finally it just won't start, it turns over fine has good spark Attached Images image.jpg (27.5 KB)
View ArticleClik here to view.
Help identifying a part on a G8 (gas)
power washed cart and found this part on the ground the part is about 4 inches in length , also cart will not stop cranking when I release pedal.. Attached Images 20160316_200927.jpg (232.7 KB)
View ArticleDPI 48v-13v reducer install.
Hey everybody, I have a DPI 36/48 volt converter with the bare leads, includes a trigger wire. The cart is a 2000 TXT series Shuttle 2+2, with "Factory" headlights, brakelights, signals, horn, and a ....
View Articlepowerdrive 17935 charger issues
i have a powerdrive on board charger 17935. it don't turn on and charge is the issue. i'm running a 4 12vdc battery set up. the batteries are 46.5vdc, plug in the charger and nothing. if i jump the...
View Articlemotor shake
04 club car precedent, new controller xct 400. I have been ridding and all was well. Today I stopped at stop sign and when I went to take off cart (motor)would shake. Got it back to the house and...
View ArticleMuffler Surgery
My 84 2pg muffler guts are rattling and it's louder than it should be and I'm worried about it affecting performance and overall flow. I plan on cutting the muffler apart and refabbing the guts rather...
View ArticleEzgo 1994 solenoid replaced cart still will not run
I have a 1994 ezgo and the solenoid has been replaced but cart will still not run. When I test the solenoid with the voltmeter it does not register.
View Article2011 G29 clicking won't run until several pumps of the pedal - voltage...
I have a 2011 Yamaha g29 "drive" (gas) that clicks when the gas pedal is pressed, but will not start. After several pumps of the pedal and a few clicks later it will eventually take off. However, this...
View ArticleClik here to view.
Club Car 2001-2002 Gasoline Service Manual 102190007
Came across this today and don't have a use for it. It is the service manual for CC Gas vehicles from 2001-2002. CC part number 102190007. Asking $30 shipped. Thanks. Attached Images manual1.jpg (183.4...
View ArticleClik here to view.
Help Identify Carryall Front End Part
I have a 2003 48V Turf 1 Carryall that needs some front end work...on the passengers side, there are what appear to be 2 tie rods? The uppermost one is the one that needs replaced. Does anyone have a...
View ArticleYamaha G9 engine swap....
My dad and I are rebuilding the engine in our G9 and we've been told that there is a pretty decent chance we will need a new motor. We're wondering what motor is the best to go with for the price, and...
View ArticleWhats the secret to getting the steering wheel off?
I got the nut loose, but I can't get the wheel off the shaft. Do I just whack it a couple times with a hammer, or continue to nearly bend it in half trying to pull on it? :help:
View ArticleClik here to view.
G16 clutch
I dont know much about the clutch assembly but the roller is flat is that normal I posted a pic to show Attached Images image.jpg (133.9 KB)
View ArticleXCT500Pds ajdustment
This is probably a question for Scotty, but wanted to throw it out there. I installed the xct500pds and D&D ES7651 motor in my cart at the end of last summer and it has been great. I have noticed...
View ArticleG8 only runs when big posts are jumped
Any idea what this would diagnose? G8 runs when I jump the two large posts on the solenoid.
View Article2003 EZGO pds rear end noise
Got a 2003 ezgo pds with rear end noise,we hit a cement block,busted a hole in rear end pan,upon inspection of teeth shown in rear end,I see no damage,cart runs fine but just has new clicking...
View ArticleNeed Torque
Ok, 2013 Precedent, new batteries. Was supposed to have speed turned up when I bought it, speed code 4 is my guess from what I've read here? Runs pretty good on flat ground but my neighborhood has some...
View Article2004 ezgo pds
MY EZGO ELECTRIC CART SUDDENLY STARTED TO RUNNING ONE SLOW SPEED FORWARD OR REVERSE. I PUT A NEW SPEED SENSORON MOTOR AND A NEW SOLENOID. SAME THING. AlSO THE NEW SOLENOID INSTALLED AND I HAVE NO...
View Article97 ezgo no reverse
i just got a 97 ezgo that goes forward just fine but will not go in reverse. Does anyone have a wiring diagram for this ? It is a series motor, after looking at the basic non dcs wiring diagram it...
View Article