No start unless jumped on solenoid
I have a 91 Club Car gas that I have checked all connections and test relay on pedals and unable to get to turn over. If I jumped the solenoid I can get the motor to turn over. If I disconnect the kill...
View ArticleClik here to view.
Help identify this , Not sure what brand or model...
I recently purchased this little cart for my campsite and have no clue who made it or what the model number is. I have found that the wheel hub caps have the Yamaha emblem but other than that, no...
View ArticleElectric to gas no reverse
I just had a 94 marathon given to me. It was electric then someone installed what looks to be an old Briggs motor. I got it running then fibered out the pully system. I have no clue if the rear end is...
View Articletire size power drain?
Im running 23x11x12 rear and 23x10x12 front with 7" lift. they say with full charge I should get 10-15 miles. My question is with this tire size how much difference should I be planning on loosing?...
View ArticleCarb Question on 1993 FE-350 Engines
I have a 1993 Carryall II with the FE-350 engine. The engine has begun to spit and sputter when I take off like it's starving for gas but runs fine when I get up to a constant speed. I've replaced the...
View ArticleNew motor and controller now cart batterys die
2012 yamaha drive After my new motor and controller my cart dies after it sits a week. What did i do wrong? Our camping season starts in 2 weeks and need a fix! Thanks
View ArticleIgnition short
I have just bought a Club car DS 2009 48 volt electric and had it stolen. I have retrieved it, but it had an ignition problem as they tried to start it with a screw driver. I have endeavoured to dig...
View ArticleDifference between workhorse & PMT
Is there a difference between WH 1200 & PMT 1200? If so, what? I have a 07 EZGO PMT 1200 & looking for owners/service manuals Looking to do some upgrades/Mods Thanks :help:
View ArticleG22 fuel pump prob
I replaced the fuel pump and the starter brushes on this g22 seems like the fuel filter is not full all the time like it is not pumping enough...I put the black plastic pump on ...shld I replace with....
View Article20 up Honda gx 620 swap
I just picks this motor I had lots of questions scattered all over this form so I'm just going to start a new build thread. So here is where I'm at I was told vc would have te exhaust I need and was...
View ArticleDPI Charger for RXV
My Powerwise QE just isn't fully charging my 3 year old US Batts. I run the cart for 18 holes 3 days a week, but the other days the cart gets only short trips of less than a mile. I always plug the...
View ArticleTire wear
2003 ds. Just noticed the outside 1/3 of front driver side tire is starting to wear much more than the other 2/3 of tire. Tire pressure is 15#. It does tend to pull to the left a little but I took that...
View ArticleI am either a genius or an idiot but I figured it out
For months I have been trying to figure out why I couldn't get my cart to idle down past a certain point. Lockman has been a big help through all this although at times we didn't always agree but this...
View Articleneed help identifying the right part number
Once again back to working on my buddies txt, this time the outer tie rod ends need to be replaced. The cart is a 2000 I think the tie rods ends have male threads, the ones I keep finding on the net...
View Article98 Clucbcar DS Gas starter replaced still not running
I have a 98 DS with FE290, have been hearing squealing when starting sometimes it would take a while before starter would turn over then car would run good till stopped then same thing again. Changed...
View ArticleTurn signal bulbs and wiring for 2016 Express L6?
Anyone know where to get the correct bulbs, and what size they might be for an Express L6? I want to add turn signals, but the orange lights, are just for looks from factory. No bulbs, holders, or...
View ArticleClik here to view.
My new cart!
Got my new cart and already started the mods. Oh yeah! Attached Images IMG_2241.jpg (157.0 KB) IMG_2278.jpg (131.3 KB) IMG_2283.jpg (128.9 KB) IMG_2285.jpg (92.1 KB) IMG_2242-1.jpg (69.1 KB)
View ArticleExpandable or removable cargo bed for fold down seat?
I saw the Madjax kit for their seats, but can't find anything for stock seats. i like the way their expandable cargo tray moved out of the way and folded into the rear seat when the seats were being...
View ArticleWTB Used Club Car front spindles for trailer project
Looking to buy used Club Car front spindles to use on a trailer project I'm building.
View Article