92 club car electric golf cart wont move
I purchased a 92 club car electric golf cart. It will not run. I found A bad microswitch and replaced it. Two of my batteries were bad so for diagnostic purposes only I put 12 volt on the cart. If I...
View ArticleEarly Nineties Club Car Solenoid question
I'm helping a friend with an early 90s Club Car resistor cart. We've narrowed it down to a bad solenoid. In my extra parts I found a brand new one but it has no part number on it. All it says is Club...
View ArticleTow bar
Has any body made tow bar for towing another cart. I do see them for sale but let's face it, 'I'm cheap"! Occasionally I end up towing somebodies cart home to repair. Flat paved roads here in the...
View Article96 DS 48v loosing power
Ok, here we go. I've got a 96 Club Car DS I use as a hunting cart. Over the past year I doesn't seem to have the power or speed that it used to. (Not to say that it had a lot to begin with) Its got new...
View ArticleDrill into cart body
If I want to drill into the cart body a hole big enough to put in an accessory cigarette plug that will run to my 12 Volt battery, what is the best way to drill this? Is there a certain drill bit or...
View ArticleClik here to view.
Broken Motor Stud (wire connection)
Guys, I am right in the middle of a ScottyB upgrade on an early 90s shuttle. While removing the wire from the A1 terminal the stud broke. See pic. Yes, I was turning it the right way. The nuts on the...
View ArticleBig Block Engine and Clutch
If you were going to buy a Big Block engine and clutch for your cart what would you get. I currently have a 23hp Vanguard that has issues and I can't get the clutch off. So going a different direction....
View ArticlePredator 670 22hp carb adjusting
This is my second 22 hp conversion, first went in a 4x4 mule, this one in my ezgo txt. The problem im having is the engine always floods, then runs lean.it idles when it wants to, or untill the wind...
View ArticleATM or ATC Fuses
I purchased a ATM in line fuse today for a quick and easy way to fuse my front and rear lights. Will ATM work or should it be ATC? I am not sure of the difference besides one is smaller in size. Sent...
View ArticleUpgrading to SPM48500
SO I ordered a SPM48500 Controller and Solenoid kit from Carts Unlimited. I have a TXT 36v with 2 awg welding cables and new batteries. Wondering if anyone can advise me on the changes Ill notice on my...
View ArticleEZGO Series Cart Upgrade
Picked up another cart today. It is a 06 Ezgo Series workhorse cart. Even better it has a 400 Amp AXE alltrax already installed. Even so, it seems slow to me. It appears to have a HD F/R selector...
View ArticleBelt too tight?
I have my G1 I've been working on for a while. When I took it out to the trails for a couple days I had problems when my drop for my swingarm broke a weld. I did a little damage to the clutch but have...
View ArticleClik here to view.
Wanted-HD solenoid and SPM48500 controller install photos for TXT
If anyone has installed the same HD solenoid, f/r switch and controller below, can you please send/upload a photo of them installed...I have an ezgo TXT i am installing these in. I have all the...
View ArticleNo spark on my 88 Marathon...
I've been driving this cart for about 5 years and never had a problem, drove up to the house and went inside, came back out and the engine would not start, it just cranks over. Plenty of fuel, so I...
View ArticleCan a new controller wait?
Hi folks, So I'm in the midst of my first cart project and thus far here is what I've done. To start, it's a 2002 ezgo pds...I've added new batteries, a complete set of 2ga wires, a 6" spindle lift,...
View ArticleKohler command turbo
Here is something I found thought maybe someone would be interested http://m.ebay.com/itm/Kohler-Command...344?nav=SEARCH
View ArticleG1 fly wheel nut
does anyone one know the size and thread pitch of the nut on the fly wheel side of the crank?
View Article1982 HD three wheeler differential
Our 1982 Harley cart has a Spicer rear end model 820378-1. Spicer, of course lists it as "Obsolete", but I need some info. 1. There is a plastic (or rubber) diamond that says "Spicer", on the back of...
View ArticleTying into ignition wire question
very new to wiring a cart, so I feel pretty dumb asking this..... Have a 2004 TXT and I am going to install a Bluetooth unit (http://www.kicker.com/40PXIBT502) and speakers. The unit has a wire labeled...
View ArticleController Wanted>->->------>
1204-410 Controller 36/48V 225A, Nothing that was under water I have two already & one that was Nuked, Nothing requiring a mortgage payment to get ! Help A fellow Red Neck Out. :mrgreen:
View Article